John Deere Gator Forums banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-11 of 11 Results
  1. Gator 620/625
    Hey All, new to the forum. Gator starts and runs fine. Does ok on flat ground. When going up an incline it slows to a crawl. It will make it, but very slowly. Replaced the drive belt with no change. Engine seems to run fine under load just no speed. No spitting or sputtering. After changing the...
  2. Gator 620/625
    I went to my local dealership yesterday and I noticed that they had two gators out front that had two different style of beds. The beds look almost identical in size and shape. My question is, can you put the new style beds on an older gator with the metal bed? I would like to get rid of the...
  3. Gator 620/625
    I suspect I need a new motor for my 620i. Plowing snow this winter the gator started acting up and was over heating very quickly while also throwing an oil light. Only happened during heavy use, trolling around the property was fine and has continued to be fine. Until now. I had a coolant...
  4. New Member Introductions
    Just a quick introduction, we have a 620i xuv. My husband had to replace the ignition switch and we're looking for a diagram. The oem switch is coded with letters and the aftermarket switch is colors. Not sure how to rematch because I failed to take a photo of proper wiring oem style. Any and...
  5. Gator General Discussion
    Does anyone know of aftermarket shocks for the 620 gator. id hate to pay JD prices...
  6. Gator General Discussion
    I’m not getting power to the pump, I’ve been slowly rewiring and rebuilding this xuv. Tested it with a meter and am getting .12 .(the meter is right it’s not even getting one volt) Is there a relay or a fuse for the fuel pump, and where is it located. also this was in the battery compartment...
  7. Gator Parts and Products For Sale
    XUV Clutch for sale AM137896 621i USED OFF KAWASAKI ENGINE $275.00
  8. Gator Parts and Products For Sale
    So my FD620D engine grenaded on my 2009 Gator XUV 620i and is not repairable. I am in the market for at least a rebuildable engine. I'm close to Savannah GA and am willing to drive to get another engine.
  9. Gator General Discussion
    I have a fuel leak around the top of my fuel tank (Gator 620i). Looking at the blowup drawing (John Deere Parts catalog) of the tank it says the fuel gauge is part 23 and the bushing is part 24. Going down the list to the actual part number the list shows two items for part 23 - a fuel sender...
  10. Gator Roll Cages, Seats and Belts
    New Gator owner, picked up a 2008 620i. I am looking to outfit this with a windshield, roof and back panel. Some of the non-JD stuff says that it will work on the 625i, but does not mention the older 620i models. Just by looks, the ROPS/roll cage looks identical between the two. Is this...
  11. New Member Introductions
    I bought a used 2009 a few weeks ago. 700+ hrs on the meter. Replaced some tires, did an oil and filters change and fixed an exhaust shield rattle. Unit runs great, but I have distinct knock in the front left at slow speed. Since I can't duplicate the noise by bouncing the front end when...
1-11 of 11 Results
Top